油罐機械清洗方案-文庫吧在線文庫

　　

【正文】 責（1） 提供人身救護、撤離、營救和醫療處理系統。（1） 及時了解統計受災現場情況（2） 對外聯系需要援助的各個單位，包括業主方，和所在地消防部門、醫院等。A、 室內滅火（1）職工發現室內起火，應立即判斷起火部位；（2）迅速切斷油、氣、電，停止可以發生火花的一切操作；（3）如果允許，應迅速隔離或搬掉易燃易爆物品；（4）火災初期，起火面積小，可用滅火器、水、水濕的毛氈、棉被等物品，迅速撲滅；（5）若伴有濃煙和有毒氣體，應用濕毛巾或防毒面具捂住口鼻，保護呼吸；（6）若大面積起火或預見到火勢會迅速發展而不易撲滅，應立即跑出呼救，撥打119向消防部門報警。（6）若大面積起火或預測到火災會迅速發展不易撲滅，應立即撥打119向消防部門報警。（4）救時要注意不要將傷病加重，必須搞清楚原因再行動。（3）現場應急領導小組組織人員撤離易損材料（如焊材、補口材料等）。對中毒人員進行搶救，并逐級匯報。，由應急組組長報告情況，配合采取相應防范及救護措施。（2）應急小組組長接到通知后，立即停止工作，組織相關人員對傷者進行急救。, 禁止啟動其它設備,待檢測合格后打開相關閥門。，及時匯報并做好防火措施。吊裝隊應急組長必須立即向項目部應急組報告，并立即趕到現場。4 應急流程應急指揮llllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllll趙玉國陳亮llllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllll趙玉國陳亮llllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllllll趙玉國 公司總部業主及地方政府匯報建議突發事件汪峰清洗工程突發事件應急反應流程圖開始急救是是否有傷員組織人員開展救援活動、請求外援集中人員清點、待命是匯報外部求援電話火警 （消防隊）： 119醫院（急救中心）： 120匪 警： 110交通事故警： 122天氣預報 ： 121進行調查結束安全撤離是否需要撤離1． 搶險小組確定2． 救護小組確定3． 組織求援行動實施4． 后勤保障小組HSE監督員項目經理有人失蹤人員安全撤離有人受傷在集合點人員集合、待命請求外援進行醫療救護是否有人員受傷、失蹤項目經理項目部營地—電話與甲方保持聯系與施工現場保持聯系對所有的通話和聯系進行記錄。由于施工現場情況復雜，也可能出現三不管的死角，在檢查中要特別注意，一旦發現要及時協調，重新落實，消滅死角。c 編制現場文明施工管理制度，簡明扼要，把檢查責任到人，把場容管理制度化。e) 不得向排水明溝、檢查井、雨水口內傾倒垃圾、渣土等雜物。 4）嚴禁損壞庫區已有的非施工建筑物。c) 嚴格遵守環保部門規定，在22時至次日6時不進行超過國家標準噪聲限制的作業。加強職工教育工作，要求工人嚴守紀律，嚴禁各類違法行為，避免對周圍老百姓造成不良影響。c) 針對施工現場情況設置宣傳標語和黑板報，并適當更換內容，確實起到鼓舞士氣，表揚先進的作用。要分基礎施工階段、結構施工階段、裝飾施工階段分別繪制施工平面布置圖，并嚴格遵照執行。公司應急組組長根據事態情況協調和部署救援工作，必要時組織公司救援組有關成員趕赴現場指揮協調。如果現場有危險因素，要設法盡快養活和消除，防止事態擴大。（2）大風天氣造成通訊中斷應急措施。（七）停電應急預案突然停電后，事故應急處理預案立即啟動：，確認停電原因、核實來電時間。，立即清理現場，盡快恢復正常工作。（2） 與當地河道管理部門聯系，組織救生艇，救生船只進行救援。（3）切斷電源后，應立即檢查傷者傷情，重點檢查呼吸和心跳。要防止二次傷害。（2）全體職工聽到呼救后，要立即停止一切工作前往救援。（1） 負責對任何緊急情況做出正確的反應；（2） 負責召集，指揮應急小組成員；（3） 負責調動公司所屬的人力、財力、物力，接收信息保留記錄；（4） 負責應急現場的指揮或委派和緊急事件后調查、分析和處理；（5） 當暫時離開組長崗位時，應以書面形式指定代理負責人。（5） 培訓應急反應隊伍，不定期進行應急演練。駐地危害人員食用過期食品或食物為清洗干凈中毒人員傷害1313嚴把食材的質量關（正規渠道進貨）；防止食物變質；合理搭配食物。管線打壓試驗壓力傷人、管線泄漏人員傷害23318提高自我保護等安全意識，規范行為，防范人身傷害；殘油移送罐頂傾斜業主設施損壞114040施工人員定時檢尺移送線，抽吸線泄露環境污染22318施工人員定時巡檢管線人員上罐滑倒、跌落人員傷害23318遇有六級以上強風、雨雪、濃霧等惡劣氣候，不得進行露天攀登與懸空高處作業；高處作業人員應經過體檢，無恐高癥等職業禁忌癥，合格后方可上崗；注入氮氣罐頂附件密封漏氣經濟損失667252定期監測可燃氣體濃度變化施工人員定期檢查溫水清洗燙傷人員傷害12612人員穿戴勞保用品罐內可燃氣體超標業主設施損壞114040時時監測罐內可燃氣體濃度根據監測情況調整注氮量強制通風觸電人員傷害114040風機、電線等設備使用前進行嚴格檢查連接風機的電線進行防護處理罐內人工處理人員在罐內中毒、窒息人員傷害23742佩帶好防毒面具或呼吸器等防毒措施；定時輪換人員作業；設置專人監護。與作業無關人員不得靠近，專人監護。高處作業人員應經過體檢，無恐高癥等職業禁忌癥，合格后方可上崗；3管線安裝試壓有完善試壓前安排專人巡檢管線。，減少疲勞作業。，要有工作通知單。打壓試驗泄漏壓力傷人規范操作，緊固到位4罐頂作業(高空作業)a、高處作業不使用安全防護品b、勞動防護品使用不當或失效c、不符合高處作業要求人員從事高空作業d、高空作業與地面人員聯系失控e、臨邊洞口無防護、無警示f、臨時墊腳物滑移,人員滑跌g、工作平臺或臨時受力點強度不足h、上下行通道不暢通，爬行鋼結構斜撐或腳手架i、行走單梁j、滑倒或外力作用身體失衡k、雨霧、大風l、沙塵暴人員傷害。預防污染，持續發展。機械清洗工藝將清洗設備與清洗罐和污油回收罐通過臨時管線連接在一起，組成一個循環系統。：盡快救護負傷者，終止作業，緊急聯系。、工具等，須是耐壓防爆物品。，嚴守場內速度限制。穿釘子鞋，穿化纖衣服使用非防爆工具清罐中出現火花用電設備漏電打火控制措施：。、測量和試驗設備的控制建立檢驗、測量和試驗設備臺帳，如壓力表、四合一氣體檢測儀等等。③負責清罐現場所施工作業及其所需輔工作業、場地清理以及作業期間所需施工、后勤生活資源、物質設施保障的支持。，%以下。3）增加勞動力，將操作工人分成兩班或三班作業，以延長工時有效時間，縮短工期。安士青2. 計劃控制按照總工期計劃控制目標，由項目經理部對工期總目標進行細化分解，排出控制工期